發布時間：2018-05-13 13:59

  本文選題：結垢 + 配伍性��； 參考：《西安石油大學》2015年碩士論文

【摘要】：目前,在陜北的長慶油田、延長油田都存在著同一區塊不同層位采出水混合開采、混合輸送和回注現象,而且已經成為這些油田普遍采用的處理工藝,但結垢已經成為了大部分油田普遍遇到的問題。如果未通過配伍性實驗進行評價,將兩種不配伍的采出水進行混合開采和輸送或?qū)⒉慌湮榈幕旌纤�作為注入水進行回注,將會導致管線和設備的大量結垢和腐蝕,降低了儲層的滲透率,對油田的正常生產開發造成不可扭轉的傷害。如何解決采出水在混合過程中的結垢問題,是產出液混采混輸和采出水回注處理重點研究的內容之一。本文應用SY/T5523-2006標準,對定邊不同區塊非同層采出水進行了配伍性實驗研究,以離子失去量和結垢量為考察指標,以地面混合后的混配水作為回注水源,進行紅柳溝區塊非同層采出水回注可行性研究,新安邊區塊采出水與清水的混注可行性研究,油房莊區塊和周長區塊非同層產出液混采混輸工藝可行性研究,結果表明:對紅柳溝區塊采出水進行回注可行性研究,主要結垢類型為碳酸鈣。最大結垢比例為4:6,作為地面混合比例。絮凝后混合水與地層水進行配伍性實驗,無明顯結垢,配伍性較好,達到回注標準。對清水與地層水進行混注可行性研究,主要結垢類型為硫酸鋇和硫酸鍶。最大結垢比例為2:8,作為地面混合比例。絮凝后混合水與地層水進行配伍性實驗,無明顯結垢,配伍性較好,回注工藝可行。對油房莊和周長區塊不同層位產出液進行混采混輸可行性研究,混合后均大量結垢,只能分層開采和輸送。絮凝后混合水與地層水進行回注可行性研究,無明顯結垢,配伍性較好,達到回注標準。
[Abstract]:At present, in Changqing Oilfield of Northern Shaanxi, Yanchang Oilfield has mixed production, mixed transportation and back injection of different produced water in the same block, and has become a widely used treatment process in these oilfields. But scaling has become a common problem in most oilfields. If the mixture is not evaluated by compatibility experiments, the mixed extraction and transportation of two uncompatible effluent or the return injection of unmixed water as injected water will result in a large amount of scaling and corrosion of pipelines and equipment. The permeability of the reservoir is reduced and irrevocable damage is caused to the normal production and development of the oil field. How to solve the scaling problem of produced water in the mixing process is one of the key contents of the research on mixed production and transportation of produced water and reinjection treatment of produced water. In this paper, SY/T5523-2006 standard is used to study the compatibility of inhomogeneous produced water in different blocks of Dingbian. The ion loss and scaling amount are taken as the index, and the mixed water after surface mixing is used as the water source for reinjection. Feasibility study on reinjection of non-same layer produced water in Hongliugou block, mixed injection of produced water and clear water in Xinanbian block, feasibility study on mixed production and transportation technology of non-identical production liquid in Fangzhuang block and Zhouchang block, The results show that the main scaling type is calcium carbonate. The maximum scaling ratio is 4: 6, as the ground mixing ratio. The compatibility experiment of mixed water and formation water after flocculation shows that there is no obvious scaling and the compatibility is good, which reaches the standard of backinjection. The feasibility of mixing clean water with formation water is studied. The main scaling types are barium sulfate and strontium sulfate. The maximum scaling ratio is 2: 8, as the ground mixing ratio. The compatibility experiment of mixed water and formation water after flocculation shows that there is no obvious scaling, and the compatibility is good, and the reinjection process is feasible. The feasibility of mixed production and transportation of different layers of production liquid in Youfangzhuang and Zhouchang blocks is studied. After mixing a large amount of scale can only be produced and transported by stratification. The feasibility study of reinjection of mixed water and formation water after flocculation shows that there is no obvious scaling and the compatibility is good.
【學位授予單位】：西安石油大學
【學位級別】：碩士
【學位授予年份】：2015
【分類號】：TE357.6

【參考文獻】

相關期刊論文 前10條

1 肖曾利,蒲春生,時宇,宋向華;油田水無機結垢及預測技術研究進展[J];斷塊油氣田;2004年06期

2 李靜;祁萬軍;吉慶林;;油田污水處理研究[J];過濾與分離;2010年02期

3 王霞,劉衛東;火燒山油田含油污水與清水可混性研究[J];工業水處理;2003年02期

4 卞超鋒;朱其佳;陳武;尹先清;梅平;;油田注入水源與儲層的化學配伍性研究[J];化學與生物工程;2006年07期

5 李連江,曾慶輝;商河油田商二區注入水與儲層配伍性研究[J];江漢石油學院學報;2003年01期

6 李利民,唐善法,付美龍,羅躍,張煜,李海燕,黨娟華;油房莊油田含油污水處理技術研究[J];精細石油化工進展;2005年01期

7 劉偉利;;結垢配伍性試驗及預測技術[J];科技信息(學術研究);2008年07期

8 周?chē)?guó)信;郭順清;;長慶油田第一凈化廠外輸污水配伍性試驗研究[J];內蒙古石油化工;2010年23期

9 王睿,丁潔,沈自求;動靜態研究體系中CaCO_3沉積規律的理論分析及實驗研究[J];水處理技術;2000年01期

10 陳李斌,楊濤,易成高,劉志民;魏崗油田集輸系統結垢分析及清垢新技術探討[J];河南石油;2002年02期

，

本文編號：1883430